ZANUSSI
FREEZER
ZF 22 W
INSTRUCTION BOOK
GB
200364670
A/ZE/5. (03.)
IMPORTANT SAFETY INSTRUCTIONS
These warnings are provided in the interests of your safety. Ensure that you understand them all
before installing or using this appliance. Your safety is of paramount importance. If you are unsure
about any of the meanings or these warnings contact the Customer Care Department.
Prior to installation
Ice lollies can cause 'frost/freezer burns' if
consumed straight from the freezer.
Check the appliance for transport damage. Under
no circumstances should a damaged appliance be
installed. In the event of damage please contact
your retailer.
Do not remove items from the freezer if your
hands are damp/wet, as this could cause skin
abrasions or frost/freezer burns.
Bottles and cans must not be placed in the
freezer they can burst when the contents freeze.
Installation
This appliance is heavy. Care should be taken when
moving it.
Manufacturers' recommended storage times
should be adhered to. Refer to relevant
instructions.
It is dangerous to alter the specifications or attempt
to modify this product in any way.
Maintenance and Cleaning
Ensure that the appliance does not stand on the
electrical supply cable. If the supply cable is
damaged, it must be replaced by a cable available
from your local Service Force Centre.
Before cleaning, always switch off the appliance
and disconnect from the electrical supply.
When unplugging always pull the plug from the
mains socket, do not pull on the cable.
Any electrical work required to install this appliance
should be carried out by a qualified electrician or
competent person.
Servicing
Parts which heat up should not be exposed.
Whenever possible, the back of the appliance
should be close to a wall, but leaving the required
distance for ventilation, as stated in the installation
instructions.
This product should be serviced by an
authorised engineer and only genuine spare
parts should be used.
Under no circumstances should you attempt to
repair the appliance yourself. Repairs carried out
by inexperienced persons may cause injury or
serious malfunctioning. Contact your local
Service Force Centre.
The appliance should be left for 2 hours after
installation before it is turned on, in order to allow
the refrigerant to settle.
Child Safety
At the end of the Appliance Life
Do not allow children to tamper with the controls or
play with the product.
When disposing of your appliance use an
authorised disposal site.
There is a risk of suffocation! Keep packaging
material away from children!
Remove the plug and ensure that any locks or
catches are removed, to prevent young children
being trapped inside.
During Use
The Appliance and the Environment
This appliance is designed for domestic use only,
specifically for the storage of edible foodstuffs. It is
not intended for commercial or industrial use.
This appliance does not contain gasses which
could damage the ozone layer.
Containers with flammable gases or liquids can
leak at low temperatures. Do not store any
containers with flammable materials, such as spray
cans, fire extinguisher refill cartridges etc. in the
freezer.
Avoid damaging the cooling unit.
The packaging used on this appliance marked with
the
symbol is recyclable.
Frozen food should not be refrozen once it has
thawed out.
Keep this instruction book for future
reference and ensure it is passed on to any
new owner.
Do not place carbonated or fizzy drinks in the
freezer.
3
CONTENTS
Instructions for the User
Guide to use the instruction book
Important Safety Instructions
Instructions for the Installer
2
3
Technical Data
12
Installing the Appliance
Transportation, Unpacking
Location
12
12
12
13
Instructions for the User
General Information
Description of the Appliance
5
5
5
Ventilation Requirements
Door Reversal
13
14
Using the Appliance
Before Use
To Start the Appliance
Thermostat Control
6
6
6
6
Electrical Connection
Freezing
Frozen Food Storage
Thawing
Fresh
6
6
6
Making Ice Cubes
Hints and Tips
Food Storage
Energy Saving Advice
In the Event of a Power Failure
7
7
7
7
Maintenance and Cleaning
Internal cleaning
External cleaning
When the appliance is not in use
Defrosting
8
8
8
8
9
Something Not Working
Service and Spare Parts
Customer Care
9
10
10
11
Guarantee Conditions
4
INSTRUCTIONS FOR THE USER
To ensure correct operation, the appliance should
be located where the ambient temperature is
between 16-32 °C.
General information
This appliance is designed for freezing and storage of
frozen food in a domestic home.
Description of the Appliance
1. Freezing compartment
2. Rating Plate
8. Door gasket
9. Thermostat
10. Condenser
11. Air circulation
12. Compressor
13. Spacer
3. Storing compartment
4. Freezing shelf
5. Defrost water outlet
6. Ice tray
7. Feet
5
Using the Appliance
Frozen Food Storage
Before Use
When first starting the freezer or if the freezer has
been out of use for some time, we advise you to run
your appliance for at least 4 hours with the
thermostat control knob in the 'Super' position
before storing frozen food.
Remove all packaging and securing tapes. Wash
inside the appliance with lukewarm water and
bicarbonate of soda (5 ml to 0,5 litre of water). Do not
use soap or detergent as the smell may linger. Dry
thoroughly.
Do not exceed the storage period indicated by the
manufacturer.
Do not use detergents, abrasive powders,
highly perfumed cleaning products, wax
polishes or products containing alcohol.
Do not open the door frequently or leave it open
longer than is necessary.
FTo Start the Appliance
1. Allow the appliance to stand for 2 hrs after
installation.
Important
Do not put carbonated liquids in the freezer.
Ice lollies, if consumed immediately after
removal from the freezer can cause a low
temperature skin burn.
2. Plug in the appliance and switch on at the mains
supply.
3. Turn the thermostat control to 'Super' and leave to
run for 4 hours to allow the correct temperature to
be reached before placing food inside.
Do not remove items from the freezer if your
hands are damp/wet, as this could cause skin
abrasions or frost/freezer burns.
4. Turn the thermostat control knob to 'Normal'.
In the event of a power cut the food in the freezer
will not be affected if the power cut is short and
the freezer is full. Do not open the door. Should
the food begin to thaw it must be consumed
quickly and must not be re-frozen. (See Hints and
Tips)
Thermostat Control
The thermostat control knob situated on the side of
the cabinet regulates the temperature inside the
freezer.
Turning the thermostat control knob clockwise makes
the temperature progressively colder.
Thawing
Stop
-
-
-
Off
Deep frozen or frozen food, prior to being used,
can be thawed in the fridge or at room temperature,
depending on the time available. Small food items
may even be cooked from frozen, in this case
cooking will take longer.
Normal
Super
To store
To Freeze
Freezing Fresh Food
It is important that fresh food placed in the freezer is
frozen quickly and that the food already in the freezer
is heated as little as possible.
Any frozen food which is allowed to thaw
accidentally should either be eaten as soon as
possible, or thrown away. Alternatively, if the food is
uncooked and has not been completely defrosted
it can be cooked and then refrozen.
To freeze fresh food:
F
1. Turn the thermostat control knob to 'Super' 6-24
Defrosted cooked food must never be
refrozen.
hours before placing fresh food in the freezer. The
freezer will now run continuously, creating a
sufficient reserve of the temperature required.
FTo Make Ice Cubes
2. Place the food on the freezing shelf of the freezer
and leave the thermostat control knob in the 'Super'
position for a further 24 hours.
1. Fill the ice cube tray 3/4 full with cold water,
place on the freezing shelf and leave to freeze.
2. To remove the cubes twist the tray or hold it
under running water for a few seconds.
3. After 24 hours, return the thermostat control knob
to the 'Normal' position. The freezer will return to
normal storage temperature. Place the frozen food
in the storing compartment.
Never try to free an ice tray that is frozen
to the freezer shelf by using pointed or
sharp edged objects.
If the thermostat control knob is left in the
'Super' position, the freezer will not be
damaged, but energy will be wasted.
6
In the Event of a Power Failure
Hints & Tips
If there is a power failure during the storage of
frozen foods, keep the door closed. If the
temperature within your freezer should rise, do not
refreeze the food without checking its condition.
The following guidelines should assist you:
Food Storage
To obtain the best performance from your freezer:
Do not store warm food or evaporating liquid.
Ice Cream: Once thawed should be discarded.
Avoid buying frozen food if you cannot store it
straight away. The use of an insulated container is
advisable. When you arrive home, place the frozen
food in the freezer immediately.
Fruits & Vegetables: If soft should be cooked and
used up.
Breads & Cakes: Can be refrozen without danger.
Do not push food together too much, try to allow air
to circulate around each item.
Shellfish: Should be refrigerated and used up
quickly.
Do not store food uncovered.
Cooked Dishes: i.e. casseroles should be
refrigerated and used up.
Ensure that food placed in the freezer is dated and
labelled and used in date order to ensure that food
is consumed at its best.
Large Pieces of Meat: Can be refrozen providing
there are still ice crystals remaining within them.
Lean food keeps better and longer than fatty food,
salt reduces the storage time.
Small Joints: Should be cooked and can then be
refrozen as cooked dishes.
Wrap the food in polythene or aluminium freezing
bags or foil so that they adhere to the food and
provide an airtight seal.
Chicken: Should also be cooked and refrozen as a
fresh dish.
Packaging which is swollen or has traces of
refrozen water droplets on the pack could indicate
that the product has not been kept at a suitable
temperature and that it may have lost its original
quality. Partially thawed food must not be refrozen,
it must be consumed within 24 hours. Never
exceed the storage times indicated by the
manufacturer.
Energy Saving Advice
Do not install the appliance close to sources of
heat, such as a boiler or radiator or cooker.
Locate the appliance in a cool well ventilated room
and make sure that the air openings of the
appliance are not obstructed.
Avoid unnecessary frosting in the cabinet by
packing all foodstuffs into airtight packages before
placing them in the freezer.
Food which is to be frozen (when cool) should be
placed in the fridge before being transferred to the
freezer.
Try to avoid keeping the door open for long periods
or opening the door too frequently as warm air will
enter the cabinet and cause the compressor to
switch on unnecessarily often.
Ensure there are no obstructions preventing the
door from closing properly.
7
Maintenance & Cleaning
Before any maintenance or cleaning is
carried out you must DISCONNECT the
appliance from the electricity supply.
Internal Cleaning
Clean the inside and accessories with warm water and
bicarbonate of soda (5 ml to 0.5 litre of water).
Rinse and dry thoroughly.
NEVER use detergents, abrasive powders,
highly perfumed cleaning products or wax
polishes to clean the interior as these will
damage the surface and leave a strong
odour.
External Cleaning
Wash the outer cabinet with warm soapy water.
Once or twice a year dust the condenser (black grille)
and the compressor at the back of the appliance with
a brush or vacuum cleaner, as an accumulation of dust
will affect the performance of the appliance and cause
excessive electricity consumption.
When the Appliance is not in Use
When the appliance is not in use for long periods,
disconnect from the electricity supply, empty all foods
and clean the appliance, leaving the door open to
prevent unpleasant smells.
8
3. Leave the door open.
Defrosting
4. To accelerate the defrosting process place a
bowl of hot (not boiling) water inside the freezer.
The freezer compartment will become progressively
covered with frost. This should be removed with the
special plastic scraper provided whenever the
thickness of frost exceeds 6 mm (¼”).
5. When defrosting is completed, dry the interior
thoroughly.
6. Turn the thermostat control 'Super' and leave to
run for at least 4 hours.
During this operation it is not necessary to switch off
the power supply or to remove the foodstuffs.
7. Replace the previously removed food.
8. Return the thermostat control to 'Normal'.
However, when the ice becomes very thick on the
inner liner, complete defrosting should be carried out
and it is advisable to perform this operation when the
appliance is empty.
Important
A temperature rise of the frozen food packs
during defrosting may shorten their safe storage
life.
To carry out complete defrosting:
F
1. It is advisable to disconnect the appliance from the
electrical supply. If the plug is inaccessible turn the
thermostat to „Stop“.
Never use sharp metal tools to scrape off frost
from the evaporator as this could damage the
appliance beyond repair.
2. Remove any stored food, wrap in several layers of
newspaper and store in a cool place.
Something Not Working
If the appliance is not working correctly, please carry out the following checks before contacting your local
Service Force Centre.
Problem
Possible Cause
No power at the socket.
Solution
No power to the
appliance
Check there is power at the socket.
There is a power cut.
Check there is not a power cut by checking the
household lights.
The fuse has blown.
Check the fuse has not blown.
Thermostat control knob is set to „stop“.
The appliance is located in an unsuitable position.
Check the thermostat control knob setting.
The temperature in the
appliance is too high
Check the ambient temperature is within the
appliances operating limits of 16 °C to 32 °C.
The thermostat control knob is set too low.
The thermostat control is set too high.
Check that the thermostat control knob is turned to
the correct setting relative to ambient conditions.
The temperature in the
appliance is too low
Set the thermostat control knob to a lower
position.
Excessive frost and ice
has built up
The door has been left open.
Something is obstructing the door.
The door gasket is dirty.
Check the door has not been left open.
Check nothing is preventing the door from closing.
Check the door gasket is intact and clean.
Check if the appliance stands stable.
The appliance is noisy.
The appliance is not level.
If after the above checks your appliance still does not
operate correctly, contact your local Service Force
Centre.
In-guarantee customers should ensure that the
above checks have been made, as the
engineer will make a charge if the fault is not a
mechanical or electrical breakdown.
Please note that it will be necessary to provide proof
of purchase for any in-guarantee service calls.
9
Service and Spare Parts
In the event of your appliance requiring service, or if you wish to purchase spare parts please contact your
local Service Force Centre by telephoning:
08705 929929
Your telephone call will be automatically routed the Service Force Centre covering your post code area. The
adresses are listed on the following pages.
For the address of your local Service Force Centre and further information about Service Force, please visit
Before calling out an engineer, please ensure you have read the details under the heading „Something Not
Working“.
When you contact the Service Centre you will need to give the following details:
1. Your name, address and post code
2. Your telephone number
3. Clear and concise details of the fault
4. The model and serial number of the appliance (found on the rating plate)
5. The purchase date
Please note that a valid purchase receipt or guarantee documentation is required for in-guarantee
service calls.
Customer Care Department
For general enquiries concerning your Zanussi Electrolux appliance or for further information on Zanussi
Electrolux products, please contact our Customer Care Department by letter or telephone at the adresses
Customer Care Department
Zanussi Electrolux
55-77 High Street
Slough
Berkshire
SL1 1DZ
08705 727727 (*)
*calls to this number may be recorded for training purposes.
10
Guarantee Conditions
We Zanussi Electrolux undertake that if within 12
EUROPEAN GUARANTEE
months of the date of the purchase this ZANUSSI
ELECTROLUX appliance or any part thereof is proved
to be defective by reason only of faulty workmanship
or materials, the company will, at our option repair or
replace the same FREE OF CHARGE for labour,
materials or carriage on condition that:
If you should move to another country within
Europe then your guarantee moves with you to your
new home subject to the following qualifications:
The guarantee starts from the date you first
purchased your product.
The guarantee is for the same period and to the
same extent for labour and parts as exists in the
new country of use for this brand or range of
products.
The appliance has been correctly installed and
used only on the electrical supply stated on the
rating plate.
The appliance has been used for normal domestic
purposes only, and in accordance with the
manufacturer's instructions.
This guarantee relates to you and cannot be
transferred to another user.
Your new home is within the European
Community (EC) or European Free Trade Area.
The appliance has not been serviced, maintained,
repaired, taken apart or tampered with by any
person not authorised by us.
The product is installed and used in accordance
with our instructions and is only used
domestically, i.e. a normal household.
All service work under this guarantee must be
undertaken by a Service Force Centre.
The product is installed taking into account
regulations in your new country.
Any appliance or defective part replaced shall
become the Company's property.
Before you move please contact your nearest
Customer Care Centre, listed below, to give them
details of your new home. They will then ensure that
the local Service Organisation is aware of your
move and able to look after you and your
appliances.
Home visits are made between 8.30am and 5.30pm
Monday to Friday. Visits may be available outside
these hours in which case a premium will be charged.
EXCLUSIONS
This Guarantee does not cover:
France
Germany Nurenberg
Senlis
+33 (0) 344 62 29 29
+49 (0) 800 234 7378
Damage or calls resulting from transportation,
improper use or neglect, the replacemet of any light
bulbs or removable parts of glass or plastic.
Italy
Pordenone +39 (0) 0434 39 4700
Sweden
UK
Stockholm
Slough
+46 (0) 8 672 53 90
+44 (0) 1753 219897
Costs incurred for calls to put right an appliance
improperly installed or calls to appliances outside
the United Kingdom.
Appliances found to be in use within a commercial
environment, plus those which are the subject of
rental agreements.
Products of Zanussi Electrolux manufacture which
are not marketed by Zanussi Electrolux.
The guarantee is in addition to your statutory and legal
rights.
11
Instructions for the Installer
Model
ZF 22 W
50
Gross capacity (l)
Net capacity (l)
Width (mm)
Height (mm)
Depth (mm)
50
525
520
587
Energy consumption (kWh/day)
(kWh/year)
0.68
248
B
Energy class, according to EU Standards
Freezing capacity (kg/24h)
Rising time (h)
7
17
Rated power (W)
70
25
Weight (kg)
The appliance should therefore:
Installing the appliance
not be installed next to radiators, cookers or
other sources of heat
only be installed at a location where the ambient
temperature corresponds to the climate
classification, for which the appliance is
designed.
Transportation, unpacking
The appliance and the interior fitting are protected for
transport.
Remove all packaging and any adhesive tape.
Any remnants of adhesive can be removed using
white spirit.
The climate classification can be found on the serial
plate.
The following table shows which ambient
temperature is correct for each climate
classification:
After transportation the appliance must not be
switched on for 2 hours. This is to allow the
refrigerant to settle.
Cleaning
Climate Classification Ambient Temperature
Clean the accessories and the inside of the appliance
with warm water and bicarbonate of soda (5 ml to
0.5 litres of water). Rinse and dry thoroughly.
SN
N
ST
+10 to +32 °C
+16 to +32 °C
+18 to +38 °C
Do not use detergents, abrasive powders, highly
perfumed cleaning products, wax polishes or
cleaning products containing bleach or alcohol.
Location
The appliance should be positioned in a well
ventilated, dry room.
Energy use is affected by the ambient temperature.
12
Ventilation Requirements
The appliance must have adequate ventilation to
ensure correct operation.
Diagram shows the ventilation requirements when
installed:
A* Under a worktop, or cupboard.
* The clearance space of 10 cm above the appliance
may be reduced to 5 cm providing a clearance
space 2.5 cm is left on either side of the appliance.
B When freestanding
Door Reversal
If required the opening direction of the door can be
changed as follows:
To reverse the hinge assembly proceed as follows:
Disconnect the appliance from the electricity
supply.
Remove the top hinge cover.
Unscrew the 2 retaining screws, and remove the
hinge from the appliance.
Take the door off.
Unscrew the lower hinge retaining screws, and
remove the hinge according to the diagram.
Fit the lower hinge on the opposite side.
Fix the door onto the lower hinge pin.
To fit top door hinge, remove the plastic blanking
plugs carefully, and refit them in the holes left by the
hinge retaining screws.
Refit the top hinge using the 2 retaining screws,
taking care that the edge of the door is parallel with
side of the cabinet.
Replace the hinge cover.
Remove screw covers (if fitted) and handle retaining
screws. Remove blanking plugs on the opposite
side.
Relocate the handle to the opposite side and refit
retaining screws (covers if fitted), and replace the
blanking plugs.
13
Electrical Connection
Any electrical work required to install this
appliance should be carried out by a
qualified electrician or competent person.
This appliance must be earthed.
The manufacturer declines any liability should
these safety measures not be observed.
Electrical Requirements
Before switching on, make sure the electricity supply
voltage is the same as that indicated on the appliance
rating plate.
The appliance is supplied with a 13 amp plug fitted. In
the event of having to change the fuse in the plug
supplied, a 13 amp ASTA approved (BS 1362) fuse
must be used. Should the plug need to be replaced
for any reason. The wires in the mains lead are
coloured in accordance with the following code:
Green and Yellow:
Blue:
Earth
Neutral
Live
Brown:
The wire coloured green and yellow must be
connected to the terminal marked with the letter „E“ or
by the earth symbol
or coloured green and yellow.
The wire coloured blue must be connected to the
terminal „N“ or coloured black.
The wire coloured brown must be connected to the
terminal marked „L“ or coloured red.
Upon completion there must be no cut, or stray
strands of wire present and the cord clamp must be
secure over the outer sheath.
This appliance complies with the following
E.E.C. Directives:
73/23 EEC of 19.02.73 (Low Voltage Directive)
and subsequent modifications,
89/336 EEC of 03.05.89 (Electromagnetic
Compatibility
modifications.
Directive)
and
subsequent
14
© Electrolux plc 2003
ELECTROLUX HOME PRODUCTS OPERATIONS EUROPE
From the Electrolux Group. The world’s No.1 choice.
The Electrolux Group is the world's largest producer of powered appliances for kitchen, cleaning and outdoor use. More than 55 million Electrolux
Group products (such as refrigerators, cookers, washing machines, vacuum cleaners, chain saws and lawn mowers) are sold each ye ar to a value of
approx. USD 14 billion in more than 150 countries around the world.
|